Product ID:34424 GREEN FLAT LACQUER TT-L-20
MSDS Date:01/04/1994
FSC:8010
NIIN:00F036079
MSDS Number: BTVFD

RANDOLPH PRODUCTS CO

701 12TH ST
CARLSTADT, NJ 07072-0830
US

Emergency Phone: 201-438-3700

Info Phone: 201-438-3700

Cage: 77672

RANDOLPH PRODUCTS CO

830 CARLSTADT, NJ 07072-0830 US

Telephone: 201-438-3700

Cage: 77672

ACETONE; DIMETHYL KETONE; 2-PROPANONE

CAS: 67-64-1

RTECS: AL3150000

Fraction By Weight: 5%

OSHA PEL 2400 MG/CUM

ACGIH TLV: 750 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

BUTYL ACETATE (N-BUTYL ACETATE)

CAS: 123-86-4

RTECS: AF7350000

Fraction By Weight: 10%

OSHA PEL 710 MG/CUM

ACGIH TLV: 713 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ETHYL ACETATE

CAS: 141-78-6

RTECS: AH5425000

Fraction By Weight: 5%

OSHA PEL 1400 MG/CUM

ACGIH TLV: 1400 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: 10%

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM

2-BUTANONE (METHYL ETHYL KETONE) (MEK)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 10%

OSHA PEL 200 PPM

ACGIH TLV: 590 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

TOLUENE

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 25-40%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

LIGHT ALIPHATIC NAPHTHA, VM & P NAPHTHA, LACOLENE

CAS: 64742-89-8

Fraction By Weight: 10-20%

OSHA PEL 300 PPM

ACGIH TLV: 300 PPM

XYLENE, DIMETHYLBENZENE, XYLOL

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 5%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM, SKIN

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

SHORT OIL ALKYD RESIN SOLUTION

Fraction By Weight: 5%

WET NITROCELLULOSE, NITROCELLULOSE, NITRATE CELLULOSE

CAS: 9004-70-0

RTECS: QW0975200

Fraction By Weight: 15%

SHORT COCONUT ALKYD

Fraction By Weight: 5%

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:CHRONIC: LONG TERM EXPOSURE MAY CAUSE
DRYING, CRACKING & IRRITATION OF SKIN. REACTS W/SKIN PROTEIN &
MOISTURE & CAN CAUSE RASH, SCALING, BLISTERING. HIGH CONCENTRATIONS
MAY CAUSE HEADACHES & DIZZINESS , ARE ANESTEHIC, & MAY HAVE OTHER
CNS EFFECTS, INCLUDING DEATH.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:CHRONIC: LONG TERM EXPOSURE MAY CAUSE DRYING,
CRACKING & IRRITATION OF SKIN. REACTS W/SKIN PROTEIN & MOISTURE &
CAN CAUSE RASH, SCALING, BLISTERING. HIGH CONCENTRATIONS MAY CAUSE
HEADACHES & DIZZINESS , ARE ANESTEHIC, & MAY HAVE OTHER CNS
EFFECTS, INCLUDING DEATH.
Medical Cond Aggravated by Exposure:PRE-EXISTING SENSITIVITY TO
SOLVENTS.

First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. SKIN:
FLUSH W/WATER. EYES: FLUSH IMMEDIATELY W/LARGE AMOUNTS OF WATER.
INGESTION: DON'T INDUCE VOMITING. KEEP PERSON WARM & QUIET.
ASPIRATION HAZARD . OBTAIN MEDICAL ATTENTION IN ALL CASES.

Flash Point Method:SCC
Flash Point:-4F
Lower Limits:0.9
Upper Limits:12.8
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:WATER STREAM WILL SPREAD FIRE. DON'T USE WATER
HOSE STREAM. WATER MAY BE USED TO COOL CONTAINERS. USE FULL BUNKER
GEAR.
Unusual Fire/Explosion Hazard:VAPOR IS HEAVIER THAN AIR/TRAVEL
CONSIDERABLE DISTANCE TO AN IGNITION SOURCE & FLASHBACK. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.

Spill Release Procedures:AVOID BREATHING SOLVENT VAPOR. ENSURE ADEQUATE
VENTILATION. REMOVE ALL SOURCES OF IGNITION. ELIMINATE SOURCE OF
SPILL W/O RISK. APPLY ABSORBENT INERT MATERIAL. CLEAN W/BRISTLE
BROOMS, NON-SPARKING TOO LS, CLEAN DRY RAGS.

Handling and Storage Precautions:KEEP CONTAINERS TIGHTLY CLOSED.
ISOLATE FROM HEAT, SPARKS & OPEN FLAME. DRUMS SHOULD BE GROUNDED
WHEN BEING EMPTIED.
Other Precautions:DON'T INCINERATE/CUT/WELD EMPTY CONTAINERS. PROVIDE
RESPIRATORY PROTECTION AGAINST FUMES GENERATED DURING BURNING.
AVOID SKIN/EYE/VAPOR CONTACT. CONTACT LENS WEARERS SHOULD CONSULT
PROVIDER BEFORE HAN DLING.

Respiratory Protection:NIOSH/OSHA APPROVED RESPIRATOR. APPROVED
CHEMICAL/MECHANICAL FILTERS RECOMMENDED WHEN VENTILATION IS
RESTRICTED.
Ventilation:SUFFICIENT IN VOLUME/PATTERN TO KEEP AIR CONTAMINATION
Protective Gloves:REQUIRED
Eye Protection:CHEMICAL GOGGLES W/SIDE SHIELDS
Other Protective Equipment:FACESHIELD, PROTECTIVE CREAMS
Work Hygienic Practices:USE NORMAL HYGIENE PRACTICES DURING/AFTER
HANDLING THIS MATERIAL. REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
SOLVENT VAPORS SHOULD BE REMOVED FROM LOWER LEVELS OF WORK AREA &
IGNITION SOURCES SHOULD BE ELIMINATED.

Boiling Pt:B.P. Text:131-298F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:THIN GREEN LIQUID W/TYPICAL SOLVENT ODOR
Percent Volatiles by Volume:76.5

Stability Indicator/Materials to Avoid:NO
STRONG OXIDIZERS, ACIDS, ALKALIES
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME
Hazardous Decomposition Products:CO, CO2

Waste Disposal Methods:SOAK LIQUIDS W/SAWDUST/RAGS & REMOVE. FLUSH
W/WATER IF POSSIBLE. TRANSFER LIQUID TO CONTAINERS FOR
RECOVERY/DISPOSAL. WHEN DISCARDED THIS MATERIAL IS A HAZARDOUS
WASTE. DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.